Alternative Vehicle fuels and Coal gas My new Cng and propane f150's
-
- Member
- Posts: 144
- Joined: Tue. Dec. 11, 2012 9:48 pm
- Stoker Coal Boiler: axeman anderson 260
- Hot Air Coal Stoker Furnace: channing III (retired)
- Hand Fed Coal Stove: russo cw2 (backup)
- Coal Size/Type: rice chesnut nut
Recently got a Propane/Gasoline F150 2001 and a 2004 CNG truck . Both are southern trucks with low miles. I can get propane for 1.50 a gallon or $2.00 a gge ( $1.20 over the Commodity spot price) CNG is $1.60 a gge (gasoline gallon equivalent. )
Looking at the calculator for BTU's I am still burning very expensive hydrogen compared to solid hydrogen (Anthracite) Has anyone seen a good example of someone who had even small scale gassification?
Looking at the calculator for BTU's I am still burning very expensive hydrogen compared to solid hydrogen (Anthracite) Has anyone seen a good example of someone who had even small scale gassification?
- McGiever
- Member
- Posts: 10130
- Joined: Sun. May. 02, 2010 11:26 pm
- Location: Junction of PA-OH-WV
- Stoker Coal Boiler: AXEMAN-ANDERSON 130 "1959"
- Hand Fed Coal Boiler: BUCKET A DAY water heater
- Hand Fed Coal Stove: Warm Morning 414A
- Coal Size/Type: PEA,NUT,STOVE /ANTHRACITE
- Other Heating: Ground Source Heat Pump and some Solar
Solid hydrogen???...You mean solid carbon, don''t you???
-
- Member
- Posts: 144
- Joined: Tue. Dec. 11, 2012 9:48 pm
- Stoker Coal Boiler: axeman anderson 260
- Hot Air Coal Stoker Furnace: channing III (retired)
- Hand Fed Coal Stove: russo cw2 (backup)
- Coal Size/Type: rice chesnut nut
"You mean solid carbon, don''t you???" We aren't burning carbon. We burn hydrogen with oxygen to produce heat. Since our hydrogen is glued together with carbon. We heat coal to release the carbon/hydrogen bond with some of that carbon is also combined with oxygen to make co/co2. If we have any science minded people who can weigh in if my understanding is correct I'd like to know. Toyota currently is selling a pure hydrogen car, catch is hydrogen is $16.95$ a gge. https://www.toyotasantamonica.com/hydrogen-fuel-cost/
- freetown fred
- Member
- Posts: 30299
- Joined: Thu. Dec. 31, 2009 12:33 pm
- Location: Freetown,NY 13803
- Hand Fed Coal Stove: HITZER 50-93
- Coal Size/Type: BLASCHAK Nut
We were runnin propane pick ups back in the 70's up in Vt. Nothin new here! Then reg. gas prices dropped big time.
- McGiever
- Member
- Posts: 10130
- Joined: Sun. May. 02, 2010 11:26 pm
- Location: Junction of PA-OH-WV
- Stoker Coal Boiler: AXEMAN-ANDERSON 130 "1959"
- Hand Fed Coal Boiler: BUCKET A DAY water heater
- Hand Fed Coal Stove: Warm Morning 414A
- Coal Size/Type: PEA,NUT,STOVE /ANTHRACITE
- Other Heating: Ground Source Heat Pump and some Solar
Nobody here has ever seen solid hydrogen.
- Lightning
- Site Moderator
- Posts: 14669
- Joined: Wed. Nov. 16, 2011 9:51 am
- Location: Olean, NY
- Stoker Coal Boiler: Modified AA 130
- Coal Size/Type: Pea Size - Anthracite
That's not totally accurate.. Anthracite is 85-90+% fixed carbon, 2-4% hydrocarbons, small percent sulphur and 7-13% or so ash. Since coal is formed by nature and we pretty much burn it that way (other than busting it into usable pieces) all of those percentages vary a little bit from location to location. But as you can see, the reaction of Carbon with Oxygen (combustion) produces a huge majority of our heat. Only a few percent of the heat is produced from actual combustion of hydrogen.wnycoalier wrote: ↑Tue. Sep. 24, 2019 11:10 amWe aren't burning carbon. We burn hydrogen with oxygen to produce heat. Since our hydrogen is glued together with carbon. We heat coal to release the carbon/hydrogen bond with some of that carbon is also combined with oxygen to make co/co2. If we have any science minded people who can weigh in if my understanding is correct I'd like to know.
-
- Member
- Posts: 144
- Joined: Tue. Dec. 11, 2012 9:48 pm
- Stoker Coal Boiler: axeman anderson 260
- Hot Air Coal Stoker Furnace: channing III (retired)
- Hand Fed Coal Stove: russo cw2 (backup)
- Coal Size/Type: rice chesnut nut
So are we with coal having two separate exothermic reactions to generate our heat. A H-O and a C and O ? This is where my poor understanding may mislead me.
To further muddy this example if coal can be heated to release methane ch4. Then we ignite ch4 and O what is the relative heat energy from the c and o of the ch4 and the h4 and o of the ch4.
To further muddy this example if coal can be heated to release methane ch4. Then we ignite ch4 and O what is the relative heat energy from the c and o of the ch4 and the h4 and o of the ch4.
- McGiever
- Member
- Posts: 10130
- Joined: Sun. May. 02, 2010 11:26 pm
- Location: Junction of PA-OH-WV
- Stoker Coal Boiler: AXEMAN-ANDERSON 130 "1959"
- Hand Fed Coal Boiler: BUCKET A DAY water heater
- Hand Fed Coal Stove: Warm Morning 414A
- Coal Size/Type: PEA,NUT,STOVE /ANTHRACITE
- Other Heating: Ground Source Heat Pump and some Solar
Maybe coal CO is not from CH4. Actually CH4 is only a gas and found in coal seams.wnycoalier wrote: ↑Tue. Sep. 24, 2019 1:31 pmSo are we with coal having two separate exothermic reactions to generate our heat. A H-O and a C and O ? This is where my poor understanding may mislead me.
To further muddy this example if coal can be heated to release methane ch4. Then we ignite ch4 and O what is the relative heat energy from the c and o of the ch4 and the h4 and o of the ch4.
What is H4?
H makes up ~2% along with the 95% Carbon of Anthracite coal. Not much CH4 methane involved in combustion.
But a lot of CO...that is where most heat energy comes from, all before leftover CO2 finally leaves up the chimney.
- Lightning
- Site Moderator
- Posts: 14669
- Joined: Wed. Nov. 16, 2011 9:51 am
- Location: Olean, NY
- Stoker Coal Boiler: Modified AA 130
- Coal Size/Type: Pea Size - Anthracite
Anthracite only has a few % of volatile matter which consists of many different strings of hydrocarbons. CH4 (methane) might be present but only in a tiny quantity. A molecule of CH4 represents 1carbon atom with 4 hydrogen atoms bonded to it. When it burns complete with oxygen you get carbon dioxide (CO2) and water (H2O) in a 1:4 ratio respectively. This is why natural gas (methane) appeals to the "tree hugger" crowd over coal. Coal as you can imagine produces several tons of carbon dioxide per ton of coal burned. But that can of worms is for another thread
-
- Member
- Posts: 144
- Joined: Tue. Dec. 11, 2012 9:48 pm
- Stoker Coal Boiler: axeman anderson 260
- Hot Air Coal Stoker Furnace: channing III (retired)
- Hand Fed Coal Stove: russo cw2 (backup)
- Coal Size/Type: rice chesnut nut
Not interested in the Henny-Penny sky is falling co2 issue. I am trying to grasp with my limited science background those two prior posts. CO is fuel source, and conversely a byproduct of incomplete combustion so it is difficult to conceptually. So countering my first post, so assuming the stociometric works to burn CO in a i/c engine. Combining CO with O would leave nothing but Co2 and the exothermic reaction. (in real world probably some NO I'm assuming from atmospheric air being the o2 source) Thus you have a fuel source that has no hydrogen (or hydrocarbon) component. Being raised on the "hydrocarbon fossil fuel" outlook its difficult to appreciate, or in other words is that close?
- McGiever
- Member
- Posts: 10130
- Joined: Sun. May. 02, 2010 11:26 pm
- Location: Junction of PA-OH-WV
- Stoker Coal Boiler: AXEMAN-ANDERSON 130 "1959"
- Hand Fed Coal Boiler: BUCKET A DAY water heater
- Hand Fed Coal Stove: Warm Morning 414A
- Coal Size/Type: PEA,NUT,STOVE /ANTHRACITE
- Other Heating: Ground Source Heat Pump and some Solar
It is all about the carbon (C) being turned to CO2
CO comes first and is chemically unstable and wants to grab a 2nd O molecule real bad, combustion satisfys it to become the stable molecule as in CO2. And CO2 will not support combustion.
CO= fuel, CO2= no more fuel, Hydrogen= forgetaboutit
Unstable CO messes up your blood due to extended breathing of it...CO poisoning...remember...unstable
CO comes first and is chemically unstable and wants to grab a 2nd O molecule real bad, combustion satisfys it to become the stable molecule as in CO2. And CO2 will not support combustion.
CO= fuel, CO2= no more fuel, Hydrogen= forgetaboutit
Unstable CO messes up your blood due to extended breathing of it...CO poisoning...remember...unstable
-
- Member
- Posts: 144
- Joined: Tue. Dec. 11, 2012 9:48 pm
- Stoker Coal Boiler: axeman anderson 260
- Hot Air Coal Stoker Furnace: channing III (retired)
- Hand Fed Coal Stove: russo cw2 (backup)
- Coal Size/Type: rice chesnut nut
So with synthetic gas , anthracite would be poor since it has so little volatiles where lignite would be better suited? What is it in heating anthracite that frees the carbon to react to become co and then co2?
- McGiever
- Member
- Posts: 10130
- Joined: Sun. May. 02, 2010 11:26 pm
- Location: Junction of PA-OH-WV
- Stoker Coal Boiler: AXEMAN-ANDERSON 130 "1959"
- Hand Fed Coal Boiler: BUCKET A DAY water heater
- Hand Fed Coal Stove: Warm Morning 414A
- Coal Size/Type: PEA,NUT,STOVE /ANTHRACITE
- Other Heating: Ground Source Heat Pump and some Solar
Changing from a solid to a vapor.wnycoalier wrote: ↑Tue. Sep. 24, 2019 10:42 pmSo with synthetic gas , anthracite would be poor since it has so little volatiles where lignite would be better suited? What is it in heating anthracite that frees the carbon to react to become co and then co2?
- Lightning
- Site Moderator
- Posts: 14669
- Joined: Wed. Nov. 16, 2011 9:51 am
- Location: Olean, NY
- Stoker Coal Boiler: Modified AA 130
- Coal Size/Type: Pea Size - Anthracite
The answer is in your question, heat.wnycoalier wrote: ↑Tue. Sep. 24, 2019 10:42 pmWhat is it in heating anthracite that frees the carbon to react to become co and then co2?
Once coal is brought to a specific temperature (temperature of ignition) it will react with oxygen fast enough to produce enough heat to keep the reaction continuing. At that point the availability of oxygen controls the speed at which the reaction continues and its total heat output.
Sorry for the run on sentencing lol