Coal Ash Color- orange tint
-
- Member
- Posts: 76
- Joined: Sun. Dec. 08, 2019 10:05 pm
- Hand Fed Coal Stove: Vermont Castings Vigilant II, Godin 3720, Godin 3731
- Coal Size/Type: Pea, Nut and Stove Coal
I've noticed that Tractor Supply nut coal, which we believe may be Kimmel's or Reading coal, leaves a white powdery ash. The coal that I get from a local distributor leaves behind ash with an orange tint, which makes me believe that there is iron in the coal. It burns well and is less gassy than the Tractor Supply coal. I'm just curious about the source. Is this Old Company Lehigh coal? Has anyone used coal that leaves orange tinted ash?
- gaw
- Member
- Posts: 4437
- Joined: Fri. Jan. 26, 2007 2:51 am
- Location: Parts Unknown
- Stoker Coal Boiler: Keystoker KA-6
- Coal Size/Type: Rice from Schuylkill County
Red ash coal, nothing wrong with that. Most of the coal I get is red ash, some say it burns hotter, maybe it does. It can form clinkers. If it works for you there's nothing to worry about.
- McGiever
- Member
- Posts: 10130
- Joined: Sun. May. 02, 2010 11:26 pm
- Location: Junction of PA-OH-WV
- Stoker Coal Boiler: AXEMAN-ANDERSON 130 "1959"
- Hand Fed Coal Boiler: BUCKET A DAY water heater
- Hand Fed Coal Stove: Warm Morning 414A
- Coal Size/Type: PEA,NUT,STOVE /ANTHRACITE
- Other Heating: Ground Source Heat Pump and some Solar
Ash color is produced by combined impurity or mineral content within the coal.
Red/orange is by varing amounts of iron oxide within the coal.
Red/orange is by varing amounts of iron oxide within the coal.
-
- Member
- Posts: 76
- Joined: Sun. Dec. 08, 2019 10:05 pm
- Hand Fed Coal Stove: Vermont Castings Vigilant II, Godin 3720, Godin 3731
- Coal Size/Type: Pea, Nut and Stove Coal
That’s what I thought... iron. There is enough iron in this coal that a porous bag of it will leave rust stains if left outside in the rain. I was curious if anyone knew which mine this coal came from...
- Pauliewog
- Member
- Posts: 1824
- Joined: Mon. Dec. 02, 2013 12:15 am
- Location: Pittston, Pennsylvania
- Hot Air Coal Stoker Furnace: Alaska 140 Dual Paddle Feed
- Baseburners & Antiques: Fame Rosemont #20, Home Stove Works #25, Glenwood #6, Happy Thought Oak, Merry Bride #214, Sunnyside, Worlds Argand #114, New Golden Sun , & About 30 others.
- Coal Size/Type: Stove, Chesnut, Pea, Rice / Anthracite
In most anthracite preparation plants the rock is separated from the coal by using a heavy media .
Fine powdered magnetite, which is basically a type of iron ore, is mixed with water until the solution has a specific gravity of approximately 1.5
Anthracite has a specific gravity of between 1.2 and 1.47 which means it will float in a solution with a specific gravity of 1.5 and the rock will sink.
When the coal is removed it is sized and washed. The magnetite is recovered from the wash and rinse water using a magnetic separator which consists of a large roller filled with magnets with a wiper blade and is returned to the heavy media tank.
If the rinse is not adequate some of the magnetite remains on the cleaned coal. That contributes to the rust in a bag and also why some white ash seams of coal produce a pink ash when burnt.
At the end of the season. sweep up the fines in your coal bin and run a magnet thru the fines pile and any magnetite powder will stick to the magnet.
If handling your coal your hands get really black........ Its probably magnetite.
Paulie
Fine powdered magnetite, which is basically a type of iron ore, is mixed with water until the solution has a specific gravity of approximately 1.5
Anthracite has a specific gravity of between 1.2 and 1.47 which means it will float in a solution with a specific gravity of 1.5 and the rock will sink.
When the coal is removed it is sized and washed. The magnetite is recovered from the wash and rinse water using a magnetic separator which consists of a large roller filled with magnets with a wiper blade and is returned to the heavy media tank.
If the rinse is not adequate some of the magnetite remains on the cleaned coal. That contributes to the rust in a bag and also why some white ash seams of coal produce a pink ash when burnt.
At the end of the season. sweep up the fines in your coal bin and run a magnet thru the fines pile and any magnetite powder will stick to the magnet.
If handling your coal your hands get really black........ Its probably magnetite.
Paulie
- gaw
- Member
- Posts: 4437
- Joined: Fri. Jan. 26, 2007 2:51 am
- Location: Parts Unknown
- Stoker Coal Boiler: Keystoker KA-6
- Coal Size/Type: Rice from Schuylkill County
From a coal mine in Pennsylvania, that's about as close as you'll get. Even if you know the supplier they may be processing coal from multiple sources.
-
- Member
- Posts: 97
- Joined: Thu. Aug. 09, 2018 9:24 am
- Location: Chardon, Ohio
- Hand Fed Coal Stove: DS Circulator #1500 W/ blower modification
- Coal Size/Type: Nut Coal
- Other Heating: House - Propane Forced air furnace. Garage - Hydronic in the concrete floor with Pellet stove supplement.
I learned something new today , great explanation to the same question I had.
Thanks
Thanks